BIODIESEL PRODUCTION FROM WASTE FISH CANNING OIL USING COCOPEAT ASH CATALYST
DOI:
https://doi.org/10.22441/ijimeam.v5i1.19936Keywords:
Biodiesel, Composite Catalyst, Reaction Time, Cocopeat Ash, Waste Fish OilAbstract
Biodiesel is an environmentally friendly alternative fuel for diesel engines. The research studies the extraction process of biodiesel from waste produced by a fish canning factory using a heterogeneous catalyst known as cocopeat ash. The experiment was designed utilizing a completely randomized design with two factorial treatments and four repetitions. The primary factor under investigation was the composition of the catalyst, specifically 3%, 5%, and 7% w/v methanol. The second factor examined was the reaction time of either 60 minutes or 120 minutes. Data analysis revealed variations in density, viscosity, acid number, and Free Fatty Acids (FFA) in fish oil before and after refinement. The treatment that yielded the highest results was A3B2, featuring a catalyst composition of 7% and a reaction time duration of two hours, which achieved an impressive biodiesel yield of 81%. Moreover, several parameters tested for compliance with SNI-04-7182-2015 standards showed positive outcomes. These parameters include a density value measuring 876.3 kg/m³, the flash point around 160°C, iodine number reaching 16.36 g/100g, and heating value 47.47 MJ/Kg.
Downloads
References
Helwani, Z., Othman, M.R., Aziz, N. & Fernando, W. J. N. (2009). Solid heterogeneous catalysts for transesterification of triglycerides with methanol: a review. Applied Catalysis A: General, 363(1–2), 1-10.
Nurdini, D. A. (2008). Desain proses pembuatan biodiesel dari bahan baku minyak jelantah dengan katalis alami abu cocopeat [Thesis]. Institut Teknologi Bandung.
Agustian, E., Praptijianto, A., Sebayang, D., Rus, A.Z.M. and Hasan, A. (2016). Biodiesel Production from waste cooking oil by using ultrasonic Tubular Reactor. Int. J. Innov. Mech. Eng. Adv. Mater, 2(1), 31-38.
Astutik, F. E. M. (2014). Penggunaan Abu Batang Pisang Sebagai Katalis Basa Heterogen Dalam Rreaksi Transesterifikasi Minyak Goreng Bekas Pada Proses Pembuatan Biodiesel [Thesis]. Politeknik Negeri Jember.
Helwani, Z., Othman, M.R., Aziz, N. & Fernando, W. J. N. (2009). Solid heterogeneous catalysts for transesterification of triglycerides with methanol: a review. Applied Catalysis A: General, 363(1–2), 1-10.
Manullang, W. F. (2016). 1,2 -dimetil-1, 2,2-tetrafeildisilana sulfonat sebagai katalis reaksi transesterifikasi CPO (Crude Palm Oil) berkadar asam lemak bebas tinggi untuk menghasilkan biodiesel [Thesis]. Universitas Sumatera Utara
Syarif, M. (2016). Calcium Carbide Residue (CCR) sebagai katalis basa heterogen pada reaksi transesterifikasi minyak kesambi (Schleichera Oleosa L.) [Thesis]. Politeknik Negeri Jember.
Prihandana R., Hendroko R. & Nuramin M. (2006). Menghasilkan biodiesel murah mengatasi polusi dan kelangkaan BBM. PT. Agromedia Pustaka.
Padil, Wahyuningsih, S., & Awaluddin, A. (2010). Pembuatan biodiesel dari minyak kelapa melalui reaksi metanolisis menggunakan katalis CaCO3 yang dipijarkan”. Jurnal Natur Indonesia, 13(1), 27-32.
Badan Pusat Statistik. (2015). Statistik Transportasi Darat 2015.
Demirbas, A. (1998). Combustion properties and calculation of higher heating values of diesel fuels. Petroleum Science and Technology, 6(7-8), 785-795.
Gracia-Moreno, P.J., Khanum, M., Guadix, A. & Guadix, E.M. (2014). Optimization of biodiesel production from waste fish oil. Renewable Energy, 68, 618-624
Indartono, Y.S. (2006). Mengenal biodiesel : karakterisrik, produksi, hingga performansi mesin (2). Berita Iptek Cyber Media.
Santoso, H., Kristianto, I., & Setyadi, A. (2013). Pembuatan biodiesel menggunakan katalis basa heterogen berbahan dasar kulit telur [Final report]. Universitas Katolik Parahayangan.
Azad, S. A., Wuen, L. Y., Tamrin, M. (2019). Potential of fish wastes as feedstock for biodiesel. Advances in Bioscience and Biotechnology, 10, 109-118.
Downloads
Additional Files
Published
How to Cite
Issue
Section
License
Authors who publish in IJIMEAM retain the following rights:- Author retains the copyright and grants the journal the right of first publication of the work simultaneously licensed under the Creative Commons Attribution-ShareAlike 4.0 License that allows others to share the work with an acknowledgment of the work's authorship and initial publication in this journal.
- Author is able to enter into separate, additional contractual arrangements for the non-exclusive distribution of the journal's published version of the work (e.g., post it to an institutional repository or publish it in a book) with the acknowledgment of its initial publication in this journal.
- Author is permitted and encouraged to post his/her work online (e.g., in institutional repositories or on their website) prior to and during the submission process, as it can lead to productive exchanges, as well as earlier and greater citation of the published work (See What is Open Access).
Read more about the Creative Commons Attribution-ShareAlike 4.0 Licence here: https://creativecommons.org/licenses/by-sa/4.0/.
